case study of marble powder replacement in concrete in india

case study of marble powder replacement in concrete in india

Partial Replacement of Cement With Marble Powder in Concrete

This project describes the feasibility of using the marble sludge dust in concrete production as partial replacement of cement. In INDIA, the marble and granite stone processing is one of the most thriving industry the effects if varying marble dust contents on the physical and mechanical properties of fresh and hardened concrete

Read More
Investigation on Partial Replacement of Cement with Marble ...

2020-9-4  Five concrete mixtures containing 0%, 5%, 10%, and 20% marble dust powder as cement replacement by weight basis has been prepared. Water/cement ratio (0.43) was kept constant, in all the concrete mixes. Compressive strength, split tensile strength flexural strength of the concrete mixtures has been obtained at 7 and 28 days.

Read More
A study of the chemical effect of marble and granite ...

2020-2-4  Manpreet et al. (2017a, 2017b) indicated in his study that replacing 15% of the cement content in the concrete mix at a water to cement ratio of 0.35 with marble slurry would decrease the water permeability and abrasion of the mix. Higher replacement ratios increased the density of the mix and reduced water penetration in the long term.

Read More
Re-use of waste marble dust in the production of cement ...

2014-1-15  Marble dust was used as a substitutional material for cement and sand. For concrete mixtures; marble dust was added in 0.0%, 5.0%, 7.5%, 10.0% and 15.0% as cement replacement by weight with 0.50 and 0.40 w/p ratios. Same manner was followed as sand replacement by weight with 0.50 and 0.40 w/c ratios.

Read More
Marble Powder As A Partial Replacement Of Sand - 1454 ...

V. CONCLUSION From the test results it is clearly evident that granite powder as a partial replacement of sand proves to be beneficial when Durability properties of Concrete is considered. Durability of Concrete using Granite Fines is almost same as that of reference mix (GF0), However at 30% replacement compared to other proportions yielded better durability.

Read More
Impact of marble waste as coarse aggregate on properties ...

2016-6-1  In a study by Binici et al.. the marble waste was used as 100% replacement for natural coarse aggregates by weight in concrete with constant water–cement ratio 0.4. River sand and ground blast furnace slag (GBFS) were used as fine aggregate.

Read More
Synergistic Effect of Marble Powder and Green Sand on the ...

2019-2-4  The aim of this paper is to study experimentally the effect of marble powder and green sand as partial substitute for fine aggregate on the strength and durability of M40 grade concrete. The use of metakaolin as a pozzolanic admixture by using as binder replacement is also studied to assess the properties with respect to fresh and hardened state.

Read More
IMPACT OF MARBLE DUST ON CEMENT CONCRETE PROPERTIES

2015-5-5  INFLUENCE OF MARBLE DUST AS PARTIAL REPLACEMENT OF CEMENT IN CONCRETE These materials participate in the hydraulic reactions, contributing significantly to the composition and microstructure of hydrated product. Presently large amounts of marble dust are generated in natural stone processing plants with an important impact on environment and humans. This project describes the feasibility of using the marble sludge dust in concrete production as partial replacement of cement. In INDIA

Read More
Research Article

2019-7-31  the amount of marble powder as a replacement of fly ash. Binici et al. [7] found that marble dust concrete had higher compressive strength than that of the corresponding lime stone dust and control concrete with equivalentw/c and mix proportion. Batayneh et al. [8] found that glass containing concretecompositeswasthemostconsistentcompositethan

Read More
Experimental study on replacement of fine aggregate in ...

2019-12-1  Compared to the natural sand, the manufactured sand has a better superior consistency high Strength concrete with redeemable significance instrument. In concrete , Curing is the prime key factor for the life of the concrete structures. Curing guarantees additionally to maintain an adequate temperature of concrete in its first ages, as this directly influences the rate of hydration of cement and eventually the strength improvement of concrete

Read More
Research Paper PARTIAL REPLACEMENT OF CEMENT

2012-5-16  marble sludge dust in concrete production as partial replacement of cement. In INDIA, the marble processing is one of the most thriving industry the effects if varying marble dust contents on the physical and mechanical properties of fresh and hardened concrete have been investigated. Test

Read More
Publications

"Long term strength and durability parameters of hardened concrete on partially replacing cement by dried waste marble powder slurry." Construction and Building Materials 198 (2019): 553-569. Singh M, Srivastava A, Bhunia D (2019) Analytical and Experimental Investigations on Using Waste Marble Powder in Concrete.

Read More
Green Concrete - Madhav University

Green concrete capable for sustainable development is characterized by application of industrial wastes to reduce consumption of natural resources and energy and pollution of the environment. Marble sludge powder can be used as filler and helps to reduce the total voids content in concrete.

Read More
Strength gain mechanisms of blended-cements containing ...

Strength gain mechanisms of blended-cements containing marble powder and brick powder were investigated in the presence of chemical composition changings of cement pastes. Blended Cements (BC) were prepared blending of 5% gypsum and 6%, 20%, 21% and 35% Marble Powder (MP) or 6%, 20%, 21% and 35% Brick Powder (BP) for CEMI42.5N cement clinker and grinding these portions in

Read More
CIVIL-Faculty-Achievements Adithya Institute of Technology

2020-2-1  Perarasan M , Krishnakumar S, Niranjani E, Dr. Suji D , (2016) “Experimental Study on Concrete Using Waste Marble Powder and Quarry Dust as Partial Replacement of Cement and Fine Aggregate” International Journal of Civil and Structural Engineering Research; Perarasan.

Read More
Sand Replacement Materials (SRM) in Sustainable Cement ...

This paper presents a short review of research works on the development of sustainable cementitious matrix composites with addition of potential mineral wastes as sand replacement materials. The study emphasizes on the possibility of recycling and sustain the mineral wastes from natural and industrial by-products in order to reduce the consumption of natural resources, energy and cost, and at ...

Read More
Suitability of Quarry Dust as a Partial Replacement of ...

To overcome this problem, present study is focused on the suitability to utilize the quarry dust in Self Compacting Concrete (SCC) partially as fine aggregate with the natural fine aggregates. In this work, quarry dust is used as replacement of sand in a different level (0%, 15%, 30%, 45% and 60%) for producing the SCC.

Read More
A Review of the Engineering Properties of Metakaolin Based ...

2020-10-5  Changing human lifestyle and increasing urbanisation are contributory factors to the high demand for concrete construction materials across the globe. With the imminent developments in the unpopulated marine/coastal zones, higher installation of concrete facilities is still expected. However, poor design and construction procedures coupled with inadequate materials selection and exposure to ...

Read More
Proceedings of SECON 2020 - Structural Engineering and ...

The book gathers contributions presented at the 4th National Conference on Structural Engineering and Construction Management (SECON’20), held in Angamaly, India, in May 2020. It addresses numerical modeling and simulation in structural engineering, structural dynamics and earthquake engineering.

Read More
(PDF) Design of Reinforced Concrete Structures ...

This is the first Chapter of the Book released by Oxford University Press, New Delhi, recently. Design of Reinforced Concrete Structures is designed to meet the requirements of undergraduate students of civil and structural engineering. This book

Read More
Research Paper PARTIAL REPLACEMENT OF CEMENT

2012-5-16  marble sludge dust in concrete production as partial replacement of cement. In INDIA, the marble processing is one of the most thriving industry the effects if varying marble dust contents on the physical and mechanical properties of fresh and hardened concrete have been investigated. Test

Read More
An Experimental Investigation on Strengths Characteristics ...

2015-9-18  V.M shelke Prof. P.Y.pawde et al To study the influence of partial replacement of cement with marble powder, and to compare it with the compressive strength of ordinary M30 concrete. and also trying to find the percentage of marble powder silica fume replaced in concrete that makes the strength of the concrete maximum.

Read More
Green Concrete - Madhav University

Green concrete capable for sustainable development is characterized by application of industrial wastes to reduce consumption of natural resources and energy and pollution of the environment. Marble sludge powder can be used as filler and helps to reduce the total voids content in concrete.

Read More
Proceedings of SECON 2020 - Structural Engineering and ...

The book gathers contributions presented at the 4th National Conference on Structural Engineering and Construction Management (SECON’20), held in Angamaly, India, in May 2020. It addresses numerical modeling and simulation in structural engineering, structural dynamics and earthquake engineering.

Read More
(PDF) Design of Reinforced Concrete Structures ...

This is the first Chapter of the Book released by Oxford University Press, New Delhi, recently. Design of Reinforced Concrete Structures is designed to meet the requirements of undergraduate students of civil and structural engineering. This book

Read More
Review Article Mechanical Properties of Polymer Concrete

2019-7-31  on the properties of polymer concrete as reported by various researchers. Amicro llerisalsoo enaddedtopolymerconcretemix to reduce the void content in aggregate mixture and thereby increase the strength of polymer concrete. e micro ller is a ne powder with a particle size less than microns. Use of calcium carbonate, y ash, and silica fume has been

Read More
REPAIR, RESTORATION AND STRENGTHENING OF

2019-9-12  complete replacement of the buildings in a given area will also lead to destroying a number of social and human links. There-fore seismic strengthening of existing dam-aged or undamaged buildings can be a defi-nite requirement in same areas. Strengthening is an improvement over the original strength when the evaluation

Read More
Marble Flooring Pros and Cons - The Spruce

2020-7-28  Whenever marble is installed, purchase at least one extra box of tiles and keep them in storage. Every lot of marble tiles will have slightly different coloring and veining, and having replacement tiles from the same batch ensures that they come from the same quarry, making it much easier to match tiles if one breaks, cracks, or becomes stained.

Read More
Effect of rice husk ash on the strenght and durability of ...

2016-10-13  Different researcher gives their opinion about the replacement of RHA. Aramraks et al., (2006) did some experimental study to find out the feasibility of using ash as fine aggregate in structural grade concrete through the investigation of the physical and mechanical properties of concrete in fresh and hardened state. Aggarwal et al., (2007 ...

Read More
Conservation of historic buildings and monuments

2015-1-1  Case Studies. In this section I will report on two case studies which I researched which will highlight mistakes made in the past, ethics in conservation and the sustainability of conservation. The leaning Tower of Pisa. The leaning tower of Pisa is one of Italy’s most infamous land marks. It attracts hundreds of thousands of tourists every year.

Read More